Special offer

Copper Plumbing and Your Residential or Commercial Building

By
Home Inspector with Alliston Home Inspector

 

Copper Plumbing and Your Home

 

Older homes which have not had their plumbing distribution upgraded can sometimes experience pin hole leaks in their pipes which is the first sign that their whole plumbing supply systems may require replacement.

 

Copper pipe can be eaten away by corrosion. The common causes of corrosion are; PH of water, O2 in water, presence of minerals, temperature of water and the velocity of the water.

 

Water PH – This is an issue where the PH is low. Low PH can lead to early corrosion of pipes which can be avoided with water treatment systems. (water softeners) This option is usually not available to apartment buildings etc where the consent of all tenants would be required.

 

Oxygen – Introducing fresh oxygen to your water system is supplying organisms that eat away at your plumbing distribution system.

 

Minerals – The coating of minerals on your plumbing distribution systems can sometimes protect and slow down the corrosion process happening in your copper pipes.

 

Water Temp – High water temperatures increase the rate of corrosion. Organisms thrive in warmer water which greatly accelerates the damage to your pipes.

 

Velocity -   Water travelling at a faster rate “scours” the pipe from minerals etc which causes wear to pipe. Creation of water bubbles and their collapse also cause creation of pinholes through a process known as Capitation.

 

Most plumbing systems are estimated to last 20 years before replacement is necessary. Pin hole leaks usually occur on hot water lines and then move on to cold water lines which then involves the whole system where an economical decision must be made to keep repairing or replacing complete system.

 

Copper pipe comes in different grades based on the thickness of the copper pipe wall. The thicker the wall the longer life expectancy. Copper comes in three grades, M for thin wall pipe used mainly inside homes, L for thicker wall pipe, used mainly outside for water services and K, the thickest, used mainly between water mains and the water meter. Copper lasts a long time, is durable and connects well to valves.

If you are replacing your plumbing in your home ensure you know type of copper pipe is being installed. Upgrading to thicker pipe is not an expensive procedure where labour is the major cost.

Copper should not be installed if the water has a PH of 6.5 or less.   The majority of public utilities supply water at a PH between 7.2 and 8.0 .   Many of the utilities that have source water with a PH below 6.5 are treating the water to raise the PH.  Private well water systems often have a PH below 6.5.   When this it the case, installing a treatment system to make the water less acidic becomes a good idea.

If your water is highly corrosive or has other problems, PEX is now used in many new homes and plumbing retrofits.

PEX is an acronym for cross-linked polyethylene. The "PE" refers to the raw material used to make PEX (Polyethylene), and the "X" refers to the cross-linking of the polyethylene across its molecular chains. The molecular chains are linked into a three-dimensional network that makes PEX remarkably durable within a wide range of temperatures, pressures and chemicals.

  • Flexible, installed with fewer fittings than rigid plumbing systems. A good choice for re-piping and for new homes. Works well for corrosive water conditions.  
  • It can stretch to accommodate the expansion of freezing water and then return to its original size when water thaws. Although it is highly freeze-resistant, no material is freeze-break proof.

One issue with PEX and CPVC, as related to me by a plumber friend who lives in the country, is that mice tend to get into wall cavities and with their ability to chew through things, flexible plumbing could be susceptible to leaks.

Galvanized Plumbing – Although not used in newer homes there are some older homes that still have galvanized plumbing in their home. Insurance companies are very reluctant to insure homes with galvanized plumbing. As explained to me, galvanized plumbing corrodes from the inside out and gives no indication of impending ruptures of pressurized pipe which can lead to expensive clean ups and claims.

If you have this have this type of plumbing expect only 40 years of use from it. The main problem with the pipe is that water will be severely restricted by corrosion that eventually fills the pipe completely. Another problem is the mismatch of metals between the brass valves and the steel. Whenever steel pipe meets copper or brass, you will see rapid corrosion of the steel pipe. Dielectric unions can be used between copper and steel pipes, however some of these unions will close off flow in a short time. In some cities they prefer using a 6" brass nipple between copper and steel pipes. The problem with dielectric unions is that it breaks the grounding effect if a live electrical wire comes in contact with a pipe. Most cities will requre the two pipes to be bonded electrically to maintain the safety of grounded pipes. If your house is over 30 years old, you can plan on replacing pipes to maintain water flow.

Having your home inspected by a Professional Home inspector can fore warn you of existing and problems that may occur in the future. For Peace of Mind during your next residential or commercial purchase call the Barrie Home Inspector

 

Please visit this sites for more information on home and commercial property inspections.

Barrie Thermal Imaging Home Inspections

Barrie Home Inspections

Alliston Home Inspector

Orillia Home Inspector

Comments (7)

Marcy Fedalei
Keller Williams Realty - Spartanburg, SC

Welcome to Active Rain and thanks for sharing your ideas.

Sep 24, 2008 11:14 PM
Vicente A. Martinez
Prudential Douglas Elliman Licensed Real Estate Salesperson - Woodhaven, NY
Realtor, Brooklyn - Long Island - Queens Homes

Hi and welcome to active|rain. There are thousands of tips, tools, and tricks of the trade here. Be sure to check them out. Best of luck and see you around.

Sep 24, 2008 11:14 PM
Ron Martin
Keller Williams Realty - Spartanburg, SC
Ron Martin Team

Good morning & welcome to Active Rain, You have joined an excellent site to receive free marketing, absorb more information from others, share ideas.  Be a blogger and have fun. If you have any clients moving to the Greenville, Spartanburg, & Anderson South Carolina area we are your team. We are on all three MLS. Great blog!  Keep it up. Again Welcome!!

Sep 24, 2008 11:23 PM
Lorena Westervelt
Van West Realty - Greenville, SC
Co-Founder/Co-Owner

Hello, welcome to Active Rain! This seems like a wonderful environment to network as well as learn from others. I hope you enjoy yourself and participate often in the Active Rain environment!

Sep 25, 2008 12:06 AM
Kirk Westervelt
Van West Realty - Greenville, SC Realtor -Short Sale Expert! - Greenville, SC
Kirk Westervelt, Broker In Charge, Van West Realty - CDPE - Short Sale Agent - Home for Sale - Greenville, Simpsonvil...

Hello and welcome to Active Rain! I encourage you to learn from others, share your knowledge and experiences with all of us, enjoy yourself, and try to log in and join us in the Active Rain community as frequently as possible. I look forward to your future blogs and comments! Take care, --Kirk.

Sep 25, 2008 12:20 AM
Ginger Ryals
Prudential C Dan Joyner and Young Realtors - Spartanburg, SC

Welcome to Active Rain!! This is a great site to network and share ideas!! Have fun with it!!

Sep 25, 2008 08:46 AM
Bill Kennedy
Keller Williams Greenville Upstate - Greenville, SC
Homes For Sale Greenville SC

Welcome to Active Rain! This is a great website for building your business, as well as learning from others.  Pat yourself on the back, because you made a GREAT choice in joining the blogosphere!

Write often, and write whatever comes to mind.  Blogs about personal topics and non-real estate items are often the best.  It helps your readers to bond with you, and ends up bringing you a lot of business!

Good luck with your future blogging.  If you'd like more info on points in Active Rain, I just wrote a blog about it (click here). Feel free to ask me any questions if you need a hand!

Sep 25, 2008 01:23 PM